Effect of ultraviolet disinfection on the fouling of reverse osmosis membranes for municipal wastewater reclamation.

Membrane fouling is a prominent problem that hinders the stable and efficient operation of the reverse osmosis (RO) system for wastewater reclamation. Previous studies showed that chlorine disinfection, which was commonly used in industrial RO systems as pretreatment, could lead to significant change in microbial community structure and resulted in serious biofouling. In order to prevent biofouling during wastewater reclamation, the effect of ultraviolet (UV) disinfection on RO membrane fouling was investigated and the mechanism was also revealed in this study. With the disinfection pretreatment by UV of 20, 40 and 80 mJ/cm2, the bacteria in the feed water were inactivated significantly with a log reduction of 1.11, 2.55 and 3.61-log, respectively. However, RO membrane fouling aggravated with higher UV dosage. Especially, in the group with the UV dosage of 80 mJ/cm2, the normalized RO membrane flux decreased by 15% compared with the control group after 19-day operation. The morphology of the fouled RO membranes indicated serious biofouling in all groups. The analysis on the microbial amount of the foulants showed that the heterotrophic plate counts (HPC) and ATP content on the fouled RO membranes with and without UV disinfection were at the same level. However, the total organic carbon content of the foulants with the UV dosage of 40 and 80 mJ/cm2 was significantly higher than the control group, with higher content of proteins and polysaccharides as indicated by EEM and FTIR spectrum. Microbial community structure analysis showed that some typical UV-resistant bacteria were selected and remained on the RO membrane after disinfection with high UV dosage, including. These residual bacteria after disinfection with high UV dosage showed higher extracellular polymeric substances (EPS) secretion compared with those without UV disinfection, and thus aggravated RO membrane fouling. Thicker EPS could decrease the transmission of UV rays, and thus bacteria with higher EPS secretion might be selected after UV disinfection.