Grid-connected PV power plant induced power quality problems — Experimental evidence

This paper presents new findings on phenomena contributing to flicker and voltage variations caused by grid-connected photovoltaic (PV) inverters. The voltage variations caused by two different 6 kW single-phase grid-connected PV inverters were studied during climatic variations by varying their grid-coupling impedance. Two different methods for characterizing the PV-plant induced voltage variations were studied: the short-term flicker index (P-st) and the 10 minute very-short voltage variation value (VSV). The results clearly indicate that PV inverter power fluctuations induced by cloud shading and enhancement have a significant effect on the VSV value, but not on P-st. PV inverters have a clear effect on the P-st as well, but the main contributors are related to the inverter design rather than the power fluctuations caused by clouds. The main contributor in the elevated P-st values could be traced back to the poor design of the maximum power point tracking (MPPT) of the inverters. The MPPT caused subharmonic current variations at a frequency of approximately 8 Hz which is close to the most sensitive frequency of human eye. Another factor causing rapid voltage variations in low irradiance conditions was the current transients related to the inverter start-up and shut-down. Harmonic current distortion is also a potential PV inverter related power quality (PQ) issue. This study indicates that although the current total harmonic distortion (THD) may be very large at low power levels the total demand distortion (TDD) of the PV inverters is almost constant regardless of the output power and the harmonic current had only a very limited effect on the voltage quality even at the weakest network having a short-circuit current of I-sc=250 A. Thus, voltage variations caused by the PV inverters were the main PQ issue in the studied networks. The investigations also clearly show that a part of the power quality problems found in the PV plants are caused by the poor design of the PV inverters.